Color steel plate is common in the construction industry. It can provide shelter for people and plays a very important role in daily life. How much do you know about its anti-corrosion spraying technology? You know what? The following color steel plate manufacturers will be introduced to you. I hope they can help you.

其防腐涂層能延長彩鋼板的使用壽命，而普通油漆只能起到臨時表面覆蓋的作用，很快就會發生皮膚爆炸和脫落，不能從根本上解決腐蝕問題，防止生銹的發生。八種噴涂技術如下：

The anti-corrosion coating can prolong the service life of the color steel plate, while the ordinary paint can only play the role of temporary surface coverage, and the skin will explode and fall off soon, which can not fundamentally solve the corrosion problem and prevent the occurrence of rust. Eight spraying techniques are as follows:

1.涂料按產品規定的比例配制，攪拌均勻。養護時間應控制在30分鐘。施工應在6小時內完成。涂層間隔不得少于24小時，不得超過7天。

1. The coating shall be prepared according to the proportion specified by the product and stirred evenly. The curing time shall be controlled within 30 minutes. The construction shall be completed within 6 hours. The coating interval shall not be less than 24 hours and not more than 7 days.

2.施工用工具應清潔干燥，涂料不得與水、香蕉水、酒精溶劑、汽油等雜質混合。涂層應在準備使用后6小時內噴涂，以防止粘結，造成不必要的損失，增加施工成本。

2. The construction tools shall be clean and dry, and the coating shall not be mixed with water, banana water, alcohol solvent, gasoline and other impurities. The coating shall be sprayed within 6 hours after it is ready for use to prevent bonding, causing unnecessary loss and increasing construction cost.

3.彩鋼板廠家建議先用水槍沖洗彩鋼板瓦，然后用角磨機、鋼絲刷、鐵砂布等工具清理基面上的灰塵、污垢、毛刺、水漬、油脂、老化漆層等附著物。

3. The color steel plate manufacturer suggests to wash the color steel plate and tile with a water gun first, and then clean the dust, dirt, burr, water stain, grease, aging paint layer and other attachments on the base surface with angle grinder, steel wire brush, iron sand cloth and other tools.

4.噴涂前，用刷子或壓縮空氣將格柵表面、角落和凹槽上的灰塵清理干凈。

4. Before spraying, clean the dust on the grid surface, corners and grooves with a brush or compressed air.

5.基層表面清理合格后，方可進行噴層施工。

5. The spraying construction can be carried out only after the surface of the base course is cleaned and qualified.

6.涂裝施工應無滲漏、無銹粉。

6. The coating construction shall be free of leakage and rust powder.

7.為防止二次污染，基層表面處理后應立即噴涂一次。

7. In order to prevent secondary pollution, the base course surface shall be sprayed once immediately after treatment.

8.在雨、霧、雪和大灰塵的條件下不能進行施工。

8. Construction cannot be carried out under the conditions of rain, fog, snow and heavy dust.

以上就是為大家介紹的有關濟南彩鋼瓦廠的詳細介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以的態度,為您提供服務http://www.cheholam.com

The above is the detailed introduction of Jinan color steel tile factory. I hope it will help you If you have any questions, you are welcome to contact us We will provide you with professional service http://www.cheholam.com